河北师范大学学报—

期刊信息

刊名：河北师范大学学报（自然科学版）Journal of Hebei Normal University (Natural Science)
主办：河北师范大学
ISSN： 1000-5854
CN： 13-1061/N
中国科技核心期刊
中国期刊方阵入选期刊
中国高校优秀科技期刊
华北优秀期刊
河北省优秀科技期刊

协同采编系统

友情链接

煤气化细渣的酸-碱协同改性及其CO₂吸附特性与机理

王源源¹

李自恩²

武东升²

张岭²

薛新洲¹

杨靖¹

（1.西安工程大学城市规划与市政工程学院，陕西西安 710048； 2.陕煤集团榆林化学有限责任公司，陕西榆林 719000）
DOI： 10.13763/j.cnki.jhebnu.nse.202603005

Acid-base synergistic modification of coal gasification fine slag and its CO₂ adsorption performance and mechanism

Wang Yuanyuan¹,Li Zien²,Wu Dongsheng²,Zhang Ling²,Xue Xinzhou¹,Yang Jing¹

PDF
下载
HTML

摘要/Abstract

摘要：

为解决煤气化细渣（coal gasification fine slag,CGFS）堆存造成的环境压力与资源浪费问题，通过CGFS的酸-碱协同改性制备出低成本、具有应用潜力的CO₂吸附材料（HKCGFS）.采用热重-微分热重（TG-DTG）、傅里叶变换红外光谱（FTIR）、X射线衍射（XRD）、N₂吸附-脱附、扫描电子显微镜（SEM）和能量色散X射线光谱（EDS）等多种表征手段系统分析了改性前后材料的物化性质与孔结构演变规律.结果表明：CGFS具有良好的热稳定性，其物相以无定形组分为主，SiO₂为主要特征晶相；酸-碱协同改性显著优化了材料的孔隙结构，HKCGFS的比表面积可达208.95 m²/g，平均孔径约为4.92 nm，呈现出丰富的介孔特征.CO₂吸附性能测试结果显示：HKCGFS 的吸附行为受吸附时间、气体温度及气体压力的协同调控，吸附量随时间延长先增加后趋于平衡，随温度升高而减少，随压力升高而增加；在 25 ℃、100 kPa条件下，60 min内即可达到0.47 mmol/g的平衡吸附量，展现出良好的吸附速率与吸附容量.吸附动力学分析表明，该吸附过程符合伪一级动力学模型，等温吸附行为更符合Freundlich模型，表明HKCGFS对CO₂的吸附以物理吸附为主.

Abstract：

To address the environmental pressure and resource waste caused by the storage of coal gasification fine slag(CGFS),the low-cost and promising CO₂ adsorption material(HKCGFS) was prepared by acid-base synergistic modification of CGFS.The physical and chemical properties,as well as the evolution of pore structure of the materials before and after modification,were systematically characterized by thermogravimetry-differential thermogravimetry(TG-DTG),Fourier transform infrared spectroscopy(FTIR),X-ray diffraction(XRD),N₂ adsorption-desorption,scanning electron microscopy(SEM),and energy dispersive X-ray spectroscopy(EDS).The results showed that CGFS exhibited good thermal stability,with amorphous components as the main phase and SiO₂ as the main characteristic crystalline phase.The acid-base synergistic modification significantly optimized the pore structure of the material.And the specific surface area of HKCGFS could reach 208.95 m²/g,with an average pore diameter of approximately 4.92 nm,showing abundant mesoporous characteristics.The CO₂ adsorption performance tests indicated that the adsorption behavior of HKCGFS was synergistically regulated by adsorption time,gas temperature and gas pressure.The adsorption capacity gradually approached equilibrium with the extension of time,decreased with increasing temperature,but increased with increasing pressure.Under the conditions of 25 ℃ and 100 kPa,the equilibrium adsorption capacity of 0.47 mmol/g could be reached within 60 min,demonstrating the good adsorption rate and adsorption capacity.The adsorption kinetics analysis showed that the adsorption process conformed to the pseudo-first-order kinetic model,and the isothermal adsorption behavior was more consistent with the Freundlich model,revealing that the adsorption of CO₂ by HKCGFS was mainly physical adsorption.

关键词

关键词： 煤气化细渣；酸-碱协同改性；CO₂吸附；机制

Key words： coal gasification fine slag ; acid-base synergistic modification ; CO₂ adsorption； mechanism

参考文献 25

[1] El Alouani M,Alehyen S,El Hadki H,et al.Synergetic influence between adsorption and photodegradation of Rhodamine B using synthesized fly ash based inorganic polymer[J].Surfaces and Interfaces,2021,24:101136.DOI:10.1016/j.surfin.2021.101136.
[2] Serna-Guerrero R,Sayari A.Modeling adsorption of CO2 on amine-functionalized mesoporous silica. 2:kinetics and break-through curves[J].Chemical Engineering Journal,2010,161(1/2):182-190.DOI:10.1016/j.cej.2010.04.042.
[3] Tripoonsuk C,Limahksohn M,Chalermsinsuwan B,et al.Direct air CO2 capture in an internally circulating fluidized bed reactor:evaluating adsorption performance of Al2O3 and K2CO3/Al2O3 sorbents[J].Chemical Engineering Journal,2025,522:167473.DOI:10.1016/j.cej.2025.167473.
[4] Liu M Y,Zhang X T,Li Z H,et al.Fabrication of zirconium(Ⅳ)-loaded chitosan/Fe3O4/graphene oxide for efficient removal of alizarin red from aqueous solution[J].Carbohydrate Polymers,2020,248:116792.DOI:10.1016/j.carbpol.2020.116792.
[5] Raganati F,Alfe M,Gargiulo V,et al.Kinetic study and breakthrough analysis of the hybrid physical/chemical CO2 adsorption/desorption behavior of a magnetite-based sorbent[J].Chemical Engineering Journal,2019,372:526-535.DOI:10.1016/j.cej.2019.04.165.
[6] Yan H Y,Zhang G J,Liu J,et al.Amine-functionalized disordered hierarchical porous silica derived from blast furnace slag with high adsorption capability and cyclic stability for CO2 adsorption[J].Chemical Engineering Journal,2023,478:147480.DOI:10.1016/j.cej.2023.147480.
[7] 宁永安,段一航,高宁博,等.煤气化渣组分回收与利用技术研究进展[J].洁净煤技术,2020,26(S1):14-19.DOI:10.13226/j.issn.1006-6772.19101501. Ning Yongan,Duan Yihang,Gao Ningbo,et al.Progress of component recycling and utilization technology of coal gasification slag[J].Clean Coal Technology,2020,26(S1):14-19.
[8] Muttakin M,Mitra S,Thu K,et al.Theoretical framework to evaluate minimum desorption temperature for IUPAC classified adsorption isotherms[J].International Journal of Heat and Mass Transfer,2018,122:795-805.DOI:10.1016/j.ijheatmasstransfer.2018.01.107.
[9] Jagiello J,Kenvin J.NLDFT adsorption models for zeolite porosity analysis with particular focus on ultra-microporous zeolites using O2 and H2[J].Journal of Colloid and Interface Science,2022,625:178-186.DOI:10.1016/j.jcis.2022.06.044.
[10] Qu J S,Zhang J B,Li H Q,et al.Coal gasification slag-derived highly reactive silica for high modulus sodium silicate synthesis:process and mechanism[J].Chemical Engineering Journal,2024,479:147771.DOI:10.1016/j.cej.2023.147771.
[11] 张久朋.气化细渣制备介孔材料及在CO2捕集与树脂补强、除味中的应用[D].长春:吉林大学,2022.DOI:10.27162/d.cnki.gjlin.2022.000552. Zhang Jiupeng.Preparation of mesoporous materials by gasification fine slag and its application in CO2 capture,resin reinforcement and deodorizations[D].Changchun:Jilin University,2022.
[12] Wei X F,Liu J,Yan H Y,et al.Synthesis of large mesoporous silica for efficient CO2 adsorption using coal gasification fine slag[J].Separation and Purification Technology,2025,353:128348.DOI:10.1016/j.seppur.2024.128348.
[13] Godiya C B,Kumar S,Xiao Y H.Amine functionalized egg albumin hydrogel with enhanced adsorption potential for diclofenac sodium in water[J].Journal of Hazardous Materials,2020,393:122417.DOI:10.1016/j.jhazmat.2020.122417.
[14] Guo Y,Guo F H,Zhou L,et al.Investigation on co-combustion of coal gasification fine slag residual carbon and sawdust char blends:physiochemical properties,combustion characteristic and kinetic behavior[J].Fuel,2021,292:120387.DOI:10.1016/j.fuel.2021.120387.
[15] Miao Z K,Guo Z K,Qiu G F,et al.Synthesis of activated carbon from high-ash coal gasification fine slag and their application to CO2 capture[J].Journal of CO2 Utilization,2021,50:101585.DOI:10.1016/j.jcou.2021.101585.
[16] Igalavithana A D,Choi S W,Dissanayake P D,et al.Gasification biochar from biowaste(food waste and wood waste) for effective CO2 adsorption[J].Journal of Hazardous Materials,2020,391:121147.DOI:10.1016/j.jhazmat.2019.121147.
[17] Du M J,Huang J J,Liu Z Y,et al.Reaction characteristics and evolution of constituents and structure of a gasification slag during acid treatment[J].Fuel,2018,224:178-185.DOI:10.1016/j.fuel.2018.03.073.
[18] Zhang J P,Zuo J,Ai W D,et al.Preparation of mesoporous coal-gasification fine slag adsorbent via amine modification and applications in CO2 capture[J].Applied Surface Science,2021,537:147938.DOI:10.1016/j.apsusc.2020.147938.
[19] Liu S,Chen X T,Ai W D,et al.A new method to prepare mesoporous silica from coal gasification fine slag and its application in methylene blue adsorption[J].Journal of Cleaner Production,2019,212:1062-1071.DOI:10.1016/j.jclepro.2018.12.060.
[20] 王林涛,杨靖,夏嘉晨,等.煤气化细渣特性及其对不同染料的吸附性[J].纺织高校基础科学学报,2023,36(1):26-35.DOI:10.13338/j.issn.1006-8341.2023.01.004. Wang Lintao,Yang Jing,Xia Jiachen,et al.Characteristics of coal gasification fine slag and its adsorption properties for different dyes[J].Basic Sciences Journal of Textile Universities,2023,36(1):26-35.
[21] Han R,Zhou A N,Zhang N N,et al.Structural properties of residual carbon in coal gasification fine slag and their influence on flotation separation and resource utilization:a review[J].International Journal of Minerals,Metallurgy and Materials,2024,31(2):217-230.DOI:10.1007/s12613-023-2753-z.
[22] Checchetto R,De Angelis M G,Minelli M.Exploring the membrane-based separation of CO2/CO mixtures for CO2 capture and utilisation processes:challenges and opportunities[J].Separation and Purification Technology,2024,346:127401.DOI:10.1016/j.seppur.2024.127401.
[23] Zhang Y K,Zheng Z J,Zhang S,et al.A novel path for coal gasification fine slag high value-added utilization:preparation of high disorder level silica anode for Li+ storage[J].Chemical Engineering Journal,2025,523:168632.DOI:10.1016/j.cej.2025.168632.
[24] Zhang N N,Zhao F Q,Han R,et al.Resources recovery from coal gasification residue by combined hydrocyclone and vibrating screen and characterization of separated products[J].Process Safety and Environmental Protection,2024,184:1272-1281.DOI:10.1016/j.psep.2024.02.058.
[25] Qiao Q X,Tang B,Men X Y,et al.Synthesis of multifunctional porous carbon-silicon composites from coal gasification fine slag:adsorption of methylene blue and microwave-induced biomass catalytic pyrolysis[J].Journal of Cleaner Production,2024,435:140498.DOI:10.1016/j.jclepro.2023.140498.